Enhanced NO₂ Gas Sensing Using Ce-doped ZnO Nanostructures
J. Environ. Nanotechnol., Volume 14, No 3 (September 2025) pp. 245-252
Abstract
This study investigates the NO2 gas detection capabilities of cerium-doped zinc oxide and the effects of varying the cerium concentration. The experiment utilized spray pyrolysis, X-ray diffraction (XRD), and infrared (IR) spectroscopy, along with a mesh aluminum electrode, on thin film samples. Thermocouples monitored the heat variance with gas levels inside a sealed gas chamber using an internal gas sensor, and the sample resistance was continuously measured and recorded. XRD analysis of ZnO nanostructures revealed a hexagonal wurtzite crystal structure with distinct alignment along specific crystallographic planes. The introduction of Ce dopants caused a red shift in the absorption edge of ZnO toward higher wavelengths, extending its absorption into the visible light spectrum. The bandgap value was shifted via doping, which showed for ZnO and Ce/ZnO were 3.32, 3.24, and 3.22 eV, respectively. The FTIR spectrum revealed the presence of hydroxyl groups (OH) associated with water molecules, which can be attributed to the combined influence of two overlapping vibrational modes. The NO2 gas is a byproduct of chemical operations, with a vibrational wavenumber of 1526 cm-1. The discernible fingerprint bond of Ce–O was identified as a stretching vibration in the range of 740 cm-1 and 655 cm-1. The position of the Zn–O stretching vibration band varies depending on factors such as the dimensions, structure, and crystallinity of the ZnO nanoparticles. The gas sensing data were obtained using methods capable of detecting concentrations as low as 10 to 100 ppm. The specimen containing 10% Ce/ZnO exhibited the highest sensitivity among all samples.
Full Text
Reference
Akbari, A., Khammar, M., Taherzadeh, D., Rajabian, A., Zak, A. K. and Darroudi, M., Zinc-doped cerium oxide nanoparticles: Sol-gel synthesis, characterization, and investigation of their in vitro cytotoxicity effects, J. Mol. Struct., 1149, 771–776 (2017).
https://doi.org/10.1016/j.molstruc.2017.08.069
Akçay, N., Algün, G. and Öztel, H. O., Fabrication of ultra-sensitive humidity sensors based on Ce-doped ZnO nanostructure with superfast response and recovery time, J. Mater. Sci.: Mater. Electron., 34(20), 1565 (2023).
https://doi.org/10.1007/s10854-023-10973-y
Artini, C., Pani, M., Carnasciali, M. M., Buscaglia, M. T., Plaisier, J. R. and Costa, G. A., Structural Features of Sm- and Gd-Doped Ceria Studied by Synchrotron X-ray Diffraction and μ-Raman Spectroscopy, Inorg. Chem., 54(8), 4126–4137 (2015).
https://doi.org/10.1021/acs.inorgchem.5b00395
Babu, K. S., Reddy, A. R., Sujatha, C., Reddy, K. V. and Mallika, A. N., Synthesis and optical characterization of porous ZnO, J. Adv. Ceram., 2(3), 260–265 (2013).
https://doi.org/10.1007/s40145-013-0069-6
Bao, L. H., Lan, Y. J. and Zhang, S. F., Synthesis and Properties of Waterborne Polyurethane Dispersions with Ions in the Soft Segments, J. Polym. Res., 13(6), 507–514 (2006).
https://doi.org/10.1007/s10965-006-9073-7
Buckman, A. B. and Kuo, C., Fizeau interferometry for measuring refractive index and thickness of nearly transparent films, Appl. Opt., 17(22), 3636-3640 (1978).
https://doi.org/10.1364/AO.17.003636
Chai, B., Wang, X., Cheng, S., Zhou, H. and Zhang, F., One-pot triethanolamine-assisted hydrothermal synthesis of Ag/ZnO heterostructure microspheres with enhanced photocatalytic activity, Ceram. Int., 40(1), 429–435 (2014).
https://doi.org/10.1016/j.ceramint.2013.06.019
Chen, X., Shen, Y., Zhang, W., Zhang, J., Wei, D., Lu, R., Zhu, L., Li, H. and Shen, Y., In-situ growth of ZnO nanowire arrays on the sensing electrode via a facile hydrothermal route for high-performance NO2 sensor, Appl. Surf. Sci., 435, 1096–1104 (2018).
https://doi.org/10.1016/j.apsusc.2017.11.222
Diao, K., Xiao, J., Zheng, Z. and Cui, X., Enhanced sensing performance and mechanism of CuO nanoparticle-loaded ZnO nanowires: Comparison with ZnO-CuO core-shell nanowires, Appl. Surf. Sci., 459, 630–638 (2018).
https://doi.org/10.1016/j.apsusc.2018.07.112
Elderderi, S., Loubière, C. L., Wils, L., Henry, S., Bertrand, D., Byrne, H. J., Chourpa, I., Gueiffier, C. E., Munnier, E., Elbashir, A. A., Delaye, L. B. and Bonnier, F., ATR-IR spectroscopy for rapid quantification of water content in deep eutectic solvents, J. Mol. Liq., 311, 113361 (2020).
https://doi.org/10.1016/j.molliq.2020.113361
Fifere, N., Airinei, A., Asandulesa, M., Rotaru, A., Ursu, E. L. and Doroftei, F., Investigating the Vibrational, Magnetic and Dielectric Properties, and Antioxidant Activity of Cerium Oxide Nanoparticles, Int. J. Mol. Sci., 23(22), 13883 (2022).
https://doi.org/10.3390/ijms232213883
Gao, R., Zhang, T., Zhang, X., Gao, S., Xu, Y., Cheng, X., Gao, J., Zheng, M., Zhou, X. and Huo, L., One-step controlled synthesis of ZnO-ZnSe hollow nanospheres with surface defects for selective detection of NO22, Appl. Surf. Sci., 635, 157628 (2023).
https://doi.org/10.1016/j.apsusc.2023.157628
Ghalmi, Y., Habelhames, F., Sayah, A., Bahloul, A., Nessark, B., Shalabi, M. and Nunzi, J. M., Capacitance performance of NiO thin films synthesized by direct and pulse potentiostatic methods, Ionics, 25(12), 6025–6033 (2019).
https://doi.org/10.1007/s11581-019-03159-2
Grinter, D. C., Allan, M., Yang, H. J., Salcedo, A., Murgida, G. E., Shaw, B. J., Pang, C. L., Idriss, H., Pirovano, V. G. and Thornton, G., Ce=O Terminated CeO2, Angew. Chem. Int. Ed., 60(25), 13835–13839 (2021).
https://doi.org/10.1002/anie.202101771
He, Y., Yu, X., Li, T., Yan, L. and Yang, B., Preparation of CeO2/ZnO nanostructured microspheres and their catalytic properties, Powder Technol., 166(2), 72–76 (2006).
https://doi.org/10.1016/j.powtec.2006.05.013
Heng, C. L., Wang, T., Li, H., Liu, J. J., Zhu, J. W., Ablimit, A., Su, W. Y., Wu, H. C., Yin, P. G. and Finstad, T. G., Strong enhancement of ultra-violet emission by Ce doping of ZnO sputtered films, Mater. Lett., 162, 53–55 (2016).
https://doi.org/10.1016/j.matlet.2015.09.125
Hussain, S., Aslam, N., Yang, X., Javed, M. S., Xu, Z., Wang, M., Liu, G. and Qiao, G., Unique polyhedron CeO2 nanostructures for superior formaldehyde gas-sensing performances, Ceram. Int., 44(16), 19624–19630 (2018).
https://doi.org/10.1016/j.ceramint.2018.07.212
Jaiswal, J., Singh, P. and Chandra, R., Low-temperature highly selective and sensitive NO22 gas sensors using CdTe-functionalized ZnO filled porous Si hybrid hierarchical nanostructured thin films, Sens. Actuators B Chem., 327, 128862 (2021).
https://doi.org/10.1016/j.snb.2020.128862
Kim, K. H., Yoshihara, Y., Abe, Y., Kawamura, M. and Kiba, T., Morphological characterization of sphere-like structured ZnO-NiO nanocomposites with annealing temperatures, Mater. Lett., 186, 364–367 (2017).
https://doi.org/10.1016/j.matlet.2016.10.052
Kulandaisamy, A. J., Elavalagan, V., Shankar, P., Mani, G. K., Babu, K. J. and Rayappan, J. B. B., Nanostructured Cerium-doped ZnO thin film – A breath sensor, Ceram. Int., 42(16), 18289–18295 (2016).
https://doi.org/10.1016/j.ceramint.2016.08.156
Li, H., Qu, Y. and Zhang, X., The gas sensor utilizing CeO2 nanorods for the low temperature detection of hydrogen, Inorg. Chem. Commun., 130, 108692 (2021).
https://doi.org/10.1016/j.inoche.2021.108692
Li, R., Yabe, S., Yamashita, M., Momose, S., Yoshida, S., Yin, S. and Sato, T., Synthesis and UV-shielding properties of ZnO- and CaO-doped CeO2 via soft solution chemical process, Solid State Ion., 151(1–4), 235–241 (2002).
https://doi.org/10.1016/S0167-2738(02)00715-4
Lu, W., zhu, D. and xiang, X., Synthesis and properties of Ce-doped ZnO as a sensor for 1,2-propanediol, J. Mater. Sci.: Mater. Electron., 28(24), 18929–18935 (2017).
https://doi.org/10.1007/s10854-017-7846-x
Manisalidis, I., Stavropoulou, E., Stavropoulos, A. and Bezirtzoglou, E., Environmental and Health Impacts of Air Pollution: A Review, Front Public Health, 8, 14, (2020).
https://doi.org/10.3389/fpubh.2020.00014
Mary, J. A., Vijaya, J. J., Bououdina, M. and Kennedy, L. J., Simple microwave-assisted solution combustion synthesis of cerium and nickel-doped ZnO nanostructures: Effects on structural, morphological, optical, and magnetic properties, Superlattices Microstruct., 76, 174–185 (2014).
https://doi.org/10.1016/j.spmi.2014.09.038
Mary, J. A., Vijaya, J. J., Bououdina, M., Kennedy, L. J., Daie, J. H. and Song, Y., Investigation of structural, surface morphological, optical properties and first-principles study on electronic and magnetic properties of (Ce, Fe)-co doped ZnO, Phys. B Condens. Matter, 456, 344–354 (2015).
https://doi.org/10.1016/j.physb.2014.09.023
Mihály, J., Deák, R., Szigyártó, I. C., Bóta, A., Somfai, T. B. and Varga, Z., Characterization of extracellular vesicles by IR spectroscopy: Fast and simple classification based on amide and C-H stretching vibrations, Biochim. et Biophys. Acta (BBA)-Biomembr., 1859(3), 459–466 (2017).
https://doi.org/10.1016/j.bbamem.2016.12.005
Moslehnejad, N., Jahangiri, M., Vafaee, F. and Niasari, M. S., Synthesis and characterization of ZnO–Ce nanophotocatalyst and their application for the removal of dye (Reactive red 198) by degradation process: Kinetics, thermodynamics and experimental design, Int. J. Hydrogen Energy, 47(57), 23980–23993 (2022).
https://doi.org/10.1016/j.ijhydene.2022.05.189
Nandiyanto, A. B. D., Oktiani, R. and Ragadhita, R., How to read and interpret FTIR spectroscope of organic material, Indones, J. Sci. Technol., 4(1), 97–118 (2019).
https://doi.org/10.17509/ijost.v4i1.15806
Naqvi, A. M. S., Soleimani, H., Yahya, N. and Irshad, K., Structural and optical properties of chromium-doped zinc oxide nanoparticles synthesized by sol-gel method, AIP Conf. Proc., 1621, 530–537 (2014).
https://doi.org/10.1063/1.4898517
Orellano, P., Reynoso, J., Quaranta, N., Bardach, A. and Ciapponi, A., Short-term exposure to particulate matter (PM10 and PM2.5), nitrogen dioxide (NO2), and ozone (O3) and all-cause and cause-specific mortality: Systematic review and meta-analysis, Environ. Int., 142, 105876 (2020).
https://doi.org/10.1016/j.envint.2020.105876
Debye P. and Scherrer, P., Interference of irregularly oriented particles in X-rays, Phys. Ziet,17, 277–283, (1916)
Petruci, J. F. S., Tütüncü, E., Cardoso, A. A. and Mizaikoff, B., Real-time and simultaneous monitoring of NO, NO2, and N2O using substrate–integrated hollow waveguides coupled to a compact Fourier transform infrared (FT-IR) spectrometer, Appl. Spectrosc., 73(1), 98–103 (2019).
https://doi.org/10.1364/AS.73.000098
Prakoso, S. P., Paramarta, V., Tju, H., Taufik, A. and Saleh, R., The influence of narrow optical gap silver oxide on zinc oxide nanoparticles produced by microwave-assisted colloidal synthesis: photocatalytic studies, J. Phys. Conf. Ser., 776, 012051 (2016).
https://doi.org/10.1088/1742-6596/776/1/012051
Reddy, P. R., Jayarambabu, N., Somasai, A. K., Rao, K. V., and Aparna, Y., Structural and Morphological Studies of ZnO-CeO2 Nanocomposites, Mater. Today Proc., 3(10), 4146–4150 (2016).
https://doi.org/10.1016/j.matpr.2016.11.088
Saranya, S., Sethupathi, N., Mahalingam, P. and Sivakumar, P., Characterization and Ambiennt temperature Hydrogen Sulfide Sensing of Annealed NiO- MnO2 Thin Films Prepared via Jet Nebulizer Spray Pyrolysis, J. Environ. Nanotechnol., 13(3), 133-139(2024).
https://doi.org/10.13074/jent.2024.09.242717
Sharma, D. K., Sharma, K. K., Kumar, V. and Sharma, A., Effect of Ce doping on the structural, optical and magnetic properties of ZnO nanoparticles, J. Mater. Sci.: Mater. Electron., 27(10), 10330–10335 (2016).
https://doi.org/10.1007/s10854-016-5117-x
Shukla, S. K., Agorku, E. S., Mittal, H. and Mishra, A. K., Synthesis, characterization and photoluminescence properties of Ce3+-doped ZnO-nanophosphors, Chem. Pap., 68(2), 217-222 (2013).
https://doi.org/10.2478/s11696-013-0442-5
Shulga, A., Butusov, L., Chudinova, G. K. and Sheshko, T., Microwave-Assisted Synthesis of Cerium Doped ZnO Nanostructures and Its Optical Properties, J. Phys. Conf. Ser., 1461(1), 012162 (2020).
https://doi.org/10.1088/1742-6596/1461/1/012162
Sofiani, Z., Derkowska, B., Dalasiński, P., Wojdyła, M., Seignon, D. S., Lamrani, M. A., Dghoughi, L., Bała, W., Addou, M. and Sahraoui, B., Optical properties of ZnO and ZnO:Ce layers grown by spray pyrolysis, Opt. Commun., 267(2), 433–439 (2006).
https://doi.org/10.1016/j.optcom.2006.06.049
Srinivasan, M. P., Uthiram, C., Ayeshamariam, A., Kaviyarasu, K. and Punithavelan, N., Dielectric performance of CeO2/ZnO core–shell nanocomposite with their structural, optical and morphological properties, J. King Saud Univ. Sci., 35(2), 102508 (2023).
https://doi.org/10.1016/j.jksus.2022.102508
Sui, L., Yu, T., Zhao, D., Cheng, X., Zhang, X., Wang, P., Xu, Y., Gao, S., Zhao, H., Gao, Y. and Huo, L., In situ deposited hierarchical CuO/NiO nanowall arrays film sensor with enhanced gas sensing performance to 2, J. Hazard. Mater., 385, 121570 (2020).
https://doi.org/10.1016/j.jhazmat.2019.121570
Sun, K., Zhan, G., Zhang, L., Wang, Z. and Lin, S., Highly sensitive NO2 gas sensor based on ZnO nanoarray modulated by oxygen vacancy with Ce doping, Sens. Actuators B Chem., 379, 133294 (2023).
https://doi.org/10.1016/j.snb.2023.133294
Tauc, J., Grigorovici, R. and Vancu, A., Optical Properties and Electronic Structure of Amorphous Germanium, Phys. Status Solidi B, 15(2), 627–637 (1966).
https://doi.org/10.1002/pssb.19660150224
Tsai, Y. T., Chang, S. J., Ji, L. W., Hsiao, Y. J., Tang, I. T., Lu, H. Y. and Chu, Y. L., High Sensitivity of NO Gas Sensors Based on Novel Ag-Doped ZnO Nanoflowers Enhanced with a UV Light-Emitting Diode, ACS Omega, 3(10), 13798–13807 (2018).
https://doi.org/10.1021/acsomega.8b01882
Verma, K. C. and Kotnala, R. K., Defects-assisted ferromagnetism due to bound magnetic polarons in Ce into Fe, Co:ZnO nanoparticles and first-principle calculations, Phys. Chem. Chem. Phys., 18(7), 5647–5657 (2016).
https://doi.org/10.1039/C5CP06930K
Xin, M., Crystal Structure and Optical Properties of ZnO:Ce Nano Film, Mol., 27(16), 5308 (2022).
https://doi.org/10.3390/molecules27165308
Xu, Y. N. and Ching, W. Y., Electronic, optical, and structural properties of some wurtzite crystals, Phys. Rev. B, 48(7), 4335–4351 (1993).
https://doi.org/10.1103/PhysRevB.48.4335
Zhang, J., Chen, T., Yu, J., Liu, C., Yang, Z., Lu, H., Yin, F., Gao, J., Liu, Q., Zhang, X. and Tu, Y., Enhanced photocatalytic activity of flowerlike CuO–ZnO nanocomposites synthesized by one-step hydrothermal method, J. Mater. Sci.: Mater. Electron., 27(10), 10667–10672 (2016).
https://doi.org/10.1007/s10854-016-5166-1
Zhang, Y. G., Zhang, G. B. and Wang, Y. X., First-principles study of the electronic structure and optical properties of Ce-doped ZnO, J. Appl. Phys., 109(6), 063510 (2011).
